Information System
USA
Protection Association
USA
SPI Supplies Division
Date Effective........... September 29, 2011
(most recent revision)
Chemical Name/Synonyms... Octoil®-S Dioctylsebacate Diffusion Pump Fluid
Di-2-ethylhexyl sebacate
Emergencies
Contacting CHEMTREC:
24 Hour Emergency Use Only #'s...
Worldwide phone: 1-(703)-527-3887
Worldwide FAX: 1-(703)-741-6090
Toll-free phone: 1-(800)-424-9300 USA only
Product or Trade Name.... SPI #00031-MB, 00031-RA, 00031-XP, 00031-XK
Octoil®-S Dioctylsebacate Diffusion Pump Fluid
Synonyms................. Di-2-ethylhexyl sebacate
Chemical Formula......... (C8H17)-OOC-(C8H17)COO-(C8H17)
|
Hazardous Material Information System USA |
Health | 1 |
National Fire Protection Association USA |
|
| Fire Hazard | 1 | |||
| Reactivity | 1 | |||
| Personal Protection |
Component Name CAS # Percent EINECS/ELINCS Di-2-ethylhexyl sebacate 122-62-3 ~100 204-558-8
Emergency overview: May cause slight eye irritation. May cause skin irritation. May be harmful if swallowed. Appearance: Colorless liquid Flash Point: >215°C (Cleveland Open Cup) Target Organs: Unknown Potential Health Effects Eye: May cause slight eye irritation Skin: Prolonged or repeated skin contact may produce skin irritation Ingestion: May be harmful by ingestion. May cause irritation to mouth, throat, and stomach. Inhalation: Inhalation may cause dizziness Chronic: Unknown
Eyes: Flush with copious amounts of water for at least 15 minutes. Seek medical attention. Skin: Wash affectd area with plenty of soap and water. Seek medical attention if symptoms occur. Ingestion: Seek medical attention! Inhalation: Move victim to fresh air. Notes to Physician: Treat symptomatically and supportively.
General Information:
Wear a MESA/NIOSH approved positive pressure self-contained breathing
apparatus and firefighter turnout gear.
Extinguishing Media:
Use Water fog, chemical foam or carbon dioxide. NFPA Class II B Material. Water may cause frothing.
Flash Point: >215°C (Cleveland Open Cup)
Explosion Limits
Lower: Unknown
Upper: Unknown
General Information: Wash affected skin areas with soap and water. Prevent spill from entering seweres and open bodies of water. Spills/Leaks: Contain spill by diking with inert material, such as sand, earth, etc. Transfer spilled liquid and diking material to separate containers for disposal or recovery. Wash floor area with hot water solution of OAKITE or equivalent.
Handling: Establish and maintain safe operating procedures if this product is to be used in an elevated process. Storage: Store in tightly closed containers in cool, dry well-ventilated storage area away from all oxidizing materials.
Engineering Controls: Local exhaust for room temperature operations. Direct exhaust for operations carried out at elevated temperatures. Eyewash station available to work area. Exposure Limits: Chemical Name ACGIH NIOSH OSHA - Final PELs Di-2-ethylhexyl sebacate n/a n/a n/a OSHA Vacated PELs: n/a n/a= not available Personal Protective Equipment Eyes: Chemical safety glasses with side shields Skin: Impermeable gloves Clothing: Wear an apron or coveralls if exposure is likely to be prolonged. Respirators: Not required for normal operations.
Physical State: Liquid
Appearance: Colorless
Odor: Faint
pH: Not availabe
Vapor Pressure: .1 Torr @150°C
Vapor Density: Not available
Evaporation Rate: Nil (ether = 1)
Viscosity: Not available
Boiling Point:450-480°C at 4 mm
Freezing/Melting Point: Not available
Autoignition Temperature: Not available
Flash Point: >215°C
Decomposition Temperature: Not available
Explosion Limits:
Lower: Not available
Upper: Not available
Solubility in water: 0.01 gm/Liter
Specific Gravity/Density: 0.912
Molecular Formula:(C8H17)-OOC-(C8H17)COO-(C8H17)
Molecular Weight: Not available
Chemical Stability: Stable under normal conditions Conditions to Avoid: High temperatures Incompatibility with Other Materials: Strong oxidizers Hazardous Decomposition of Products: Will not occur under normal circumstances Hazardous Polymerization: Not known
RTECS#:
CAS# 122-62-3: VS1000000
LD50/LC50 Information:
LD50 Rat, oral > 5 g/kg
LD50 Mouse, oral 9500 mg/kg
LD50 Rabbit, dermal > 2 g/kg
Irritancy Rabbit, eye not an irritant
Irritancy Rabbit, skin not an irritant or corrosive
Carcinogenicity: Not available
ACGIH: Not available
California: Not available
NIOSH: Not available
NTP: Not available
OSHA: Not available
IARC: Not available
Teratogenicity: Not available
Reproductive Effects: Not available
Neurotoxicity: Not available
Mutagenicity: Not available
Other Studies: Not available
Exotoxicity:
Not available
Environmental Fate:
Not available
Aquatic:
LC50 Daphnia magna >1000 mg/Liter
Atmospheric:
This product does not contain any ozone depleting materials.
Physical:
Not available
RCRA P-Series: Not available RCRA U-Series: Not available Use a licensed, approved waste disposal service. Incinerate liquid in approved equipment. Dispose of contaminated diking material in a approved landfill. Dispose of in accordance with all federal, state and local environmental regulations.
US DOT Hazard Class: Not hazardous for transport IATA (for international shipments): Not hazardous for transport
United States:
TSCA
This product is listed on the TSCA Inventory.
Health & Safety Reporting List Not available
Chemical Test Rules Not available
Section 12b: Not available
TSCA Significant New Use Rule: Not available
CERCLA Section 103: Not available
SARA:
This product contains no chemicals that require reporting to SARA Section 313.
This product contains no chemicals that require reporting to SARA Title III.
This product contains no chemicals that require reporting to 40 CFR Part 372.
OSHA:
This product contains no chemicals considered to be hazardous by OSHA>
State (Individual states in the USA)
CAS# 122-62-3 is not listed on the CA, Fl, MA, MN, NJ, or PA state lists.
California No Significant Risk Level:
California Prop. 65:
This product contains no chemicals listed under California Prop. 65.
European/International Regulations:
European Labeling in Accordance with EC Directives
Hazard Symbols:
This product is not classified.
Risk Phrases:
R
Safety Phrases:
S 2 Keep out of reach of children
S 24/25 Avoid contact with skin and eyes
WGK (Water Danger/Protection):
CAS# 122-62-3: 1
Canada
This product has a WHMIS classification of: Not available
DSL/NDSL
CAS# 122-62-3 is listed on the DSL List.
CAS# 122-62-3 is not listed on the NDSL List.
If this product should be used in ways that are outside of the intended applications in scanning electron microscope laboratories, and if it is going to be formulated into some other system, so that it becomes just another component of that other system, read the MSDS sheets for the other components before blending as the resulting mixture may have the hazards of all of its parts.
Disclaimer of Liability:
Caution! Do not use SPI Supplies products or materials in applications involving implantation within the body; direct or indirect contact with the blood pathway; contact with bone, tissue, tissue fluid, or blood; or prolonged contact with mucous membranes. Products offered by SPI Supplies are not designed or manufactured for use in implantation in the human body or in contact with internal body fluids or tissues. SPI Supplies will not provide to customers making devices for such applications any notice, certification, or information necessary for such medical device use required by US FDA (Food and Drug Administration) regulation or any other statute.
SPI Supplies and Structure Probe, Inc. make no representation, promise, express warranty or implied warranty concerning the suitability of these materials for use in implantation in the human body or in contact with internal body tissues of fluids.
The information and recommendations set forth above are taken from sources believed to be accurate as of the date hereof, however SPI Supplies and Structure Probe, Inc. make no warranty with respect to the accuracy of the information or the suitability of the recommendations, and assume no liability to any user thereof. The information contained in this sheet does not constitute a hazard assessment and should not be used in place of the user's own assessment of work place risks as required by other health and safety legislation. Be aware of the Structure Probe, Inc. Copyright Policy. Structure Probe, Inc. grants a nonexclusive license to make unlimited copies of this safety sheet for internal use only. Quite obviously, this information would pertain only to this material when purchased from SPI Supplies as product from other sources, with other ingredients and impurity levels could have substantially different properties.
To Ask a Question or Make a Comment
To Place an Order or Request a Quote
